Manitowoc Ice QM45 Series Bedienungsanleitung

QM45 Series Ice Machines Installation, Use, Care, and Service Manual Thank you for selecting a Manitowoc Ice Machine, the dependability leade

Installation Instructions Section 22-2 Location of Ice Machine The location selected for the ice machine must meet the following criteria. If any

Section 2 Installation Instructions2-3 Leveling the Ice Machine 1. Screw the leveling legs onto the bottom of the ice machine. 2. Screw the foot

Installation Instructions Section 22-4 THIS PAGE INTENTIONALLY LEFT BLANK

Installation InstructionsSection 2 2-5 Electrical Service GENERAL WARNING All wiring must conform to local, state and national codes. VOLTAGE T

Installation Instructions Section 22-6 Water Service/DrainsWATER SUPPLY Local water conditions may require treatment of the water to inhibit scale

Section 2 Installation Instructions2-7 WATER SUPPLY AND DRAIN LINE SIZING/CONNECTIONS CAUTION Plumbing must conform to state and local codes. L

Installation Instructions Section 22-8 Installation Checklist Is the ice machine level? Has all of the internal packing been removed? Have all

Section 3 Ice Machine Operation3-1 Ice Machine Operation Component Identification WATER PUMP COMPRESSOR COMPARTMENT ACCESS SCREWSON/OFF/WASH

Ice Machine Operation Section 33-2 Ice Making Sequence of Operation INITIAL START-UP OR START-UP AFTER AUTOMATIC SHUT-OFF 1. Pressure Equalization

Section 3 Ice Machine Operation3-3 QM45 SELF-CONTAINED AIR COOLED MODELS ICE MAKING SEQUENCE OF OPERATION CONTROL BOARD RELAYS RELAY 1 2 3 3A 3

Safety Notices When using or servicing these Ice Machines, be sure to pay close attention to the safety notices in this manual. Disregarding the notic

Ice Machine Operation Section 33-4 Operational Checks GENERAL Your Manitowoc ice machine was factory-operated and adjusted before shipment. Normal

Section 3 Ice Machine Operation3-5 ICE THICKNESS CHECK The ice thickness probe is factory-set to maintain the ice bridge thickness at 1/8” (3.2 mm

Ice Machine Operation Section 33-6 THIS PAGE INTENTIONALLY LEFT BLANK

4-1 Section 4 MaintenanceSection 4 MaintenanceInterior Cleaning and SanitizingGENERAL Clean and sanitize the ice machine every six months for eff

4-2 Maintenance Section 4 WARNING Disconnect electric power to the ice machine at the electric switch box before proceeding. Step 6: Remove parts

4-3 Section 4 MaintenanceD. Remove the Water Distribution Tube Water Distribution Tube Removal • Loosen the two thumbscrews, which secure th

4-4 Maintenance Section 4 F. Remove the Water Trough • Apply downward pressure on the siphon tube and remove from the bottom of the water trough.

4-5 Section 4 MaintenanceH. Remove the Bin Door • Grasp the rear of the bin door and pull bin door forward approximately 5”. • Slide bin door to

4-6 Maintenance Section 4Step 12 Use 1/2 of the sanitizer/water solution to sanitize all foodzone surfaces of the ice machine and bin. Use a cloth

4-7 Section 4 MaintenanceICE MACHINE INSPECTION Check all water fittings and lines for leaks. Also, make sure the refrigeration tubing is not rub

Table of Contentsi Table of Contents Section 1 - General Information Model Numbers...

4-8 Maintenance Section 4REMOVAL FROM SERVICE WINTERIZATION Special precautions must be taken if the ice machine is to be removed from service for

Section 5 Before Calling for Service5-1 Section 5 Before Calling for Service Checklist If a problem arises during operation of your ice machine, f

Before Calling for Service Section 55-2 Problem Possible Cause To Correct Ice machine produces shallow or incomplete cubes, or the ice Ice thic

5-3 Before Calling for ServiceSection 5 SAFETY LIMITS General In addition to standard safety controls, the control board has two built in safety li

5-4 Before Calling for Service Section 5Safety Limit #1 Freeze time exceeds 60 minutes for 3 consecutive freeze cycles. Possible Cause Check/Corre

MANITOWOC ICE, INC. Web Site - www.manitowocice.com ©2006 Manitowoc Ice, Inc.

Table of Contents ii Table of Contents (cont.) Section 4 - Maintenance General...

Section 1 General Information1-1 Section 1 General Information Model Numbers This manual covers the following models: Self-Contained Air-Cooled

General Information Section 11-2 Model/Serial Number Location Record the model and serial number of your ice machine in the space provided below. T

Section 1 General Information1-3 Owner Warranty Registration Card GENERAL The packet containing this manual also includes warranty information. Wa

General Information Section 11-4 Residential Warranty Coverage WHAT DOES THIS LIMITED WARRANTY COVER? Subject to the exclusions and limitations b

Section 2 Installation Instructions2-1 Section 2 Installation Instructions General These instructions are provided to assist the qualified instal